Making Butter
Recipe instructions by Rose Adamson (born 1914)
contents © Al Durtschi
Step 1:
Collecting the cream: You must first get the cream. You do this by letting the raw whole milk sit for several hours. The cream will naturally float to the top. You can skim this off the top of the milk. We used a `cream ladle' which was a large spoon shaped piece of tin with holes in it - the holes being about 1/16 inch in diameter. The milk ran out the holes but the cream wouldn't. The cream was collected and put in the root cellar, the coldest place we had. Every morning we collected the cream from the previous day's milking and added it to the other cream we had collected. After about a week we had enough cream to make a batch of butter. Note: the colder the milk the thicker the cream. If you have the refrigeration, get the milk as cool as you can without freezing it. Otherwise put it into a cool creek if you have one handy.
Step 2:
Souring the cream: As you can imagine, our cream was already quite sour after a week of gathering the cream in a root cellar that didn't get any colder than 60 degrees F. If it was in the Winter and the cream hadn't soured, we brought it in the house and set it on the counter for 24 hours so it could begin to sour. Note: The butter will not separate easily from fresh cream if it hasn't soured
Step 3:
Get the cream temperature right: The butter will not separate from the cream if it is too hot or too cold. Room temperature is best - say 50-68 degrees. It should not be even close to the melting point of butter. If your cream has been sitting out on the counter you can ignore this step.
Step 4:
Churn your cream: Put the cream in a butter churn. Do not fill it over half full. There are two types: the vertical plunger churn and the rotating paddle churn. Which ever type you use, churn the butter in a steady and methodical motion. With a vertical plunger churn, raise it all the way up and push it all the way down in one second cycles. Gradually turn the plunger as you do this. If you have a paddle churn, turn it about one revolution every second. Separating the butter from the `butter milk' is not a fast process. Depending on conditions it could take you from 1/2 hour to forever! When one hand gets tired, switch! A different feel is one of the indications that it is getting done. It got thicker, then shortly thereafter the butter separated out. You can also take a look inside and see what progress you are making.
Step 5:
Separate the butter from the buttermilk: You can use the cream ladle or the butter paddle. This resembles a large wooden spoon 3 inches in diameter, only almost flat. Carefully scoop the floating butter off the top of the buttermilk and place it in a bowl.
Step 6:
Remove all the remaining buttermilk from the butter: Using the butter paddle, work the butter back and fourth on the sides of the bowl. As the buttermilk comes to the surface pour it out of the bowl.
Step 7:
Wash the butter: Pour a small amount of very cold water into the bowl and work the butter like you did before. As the water becomes discolored, pour it out and pour in more cold water and continue to work it. Continue this process until the water remains clear. Note: It is important to work all the buttermilk out of the butter as it will go rancid if you don't. And it will ooze and run, most distasteful to the more delicate souls among us.
Step 8:
Add salt: Sprinkle in 1 teaspoon of salt per pound of butter and mix it in. Then taste it. If it is too salty for your taste, you can put in more cold water and work it through the butter as you did before. The salt will gradually migrate into the water.
Step 9:
Put in molds: Butter molds have false bottoms for pushing the molded butter out of the mold. Pack the butter into the mold, being sure to get rid of any air bubbles. (This way, if you sell it, people won't think you are cheating them when they knife into one of them.) Then push it out of the mold and wrap in butter paper. Or you can put it into an old margarine container and put the lid on if you are keeping it for personal use.
Free Forum Hosting
Important Announcement
First 
Return to Homesteading